puch & tomos exhaust mounting set

puch & tomos exhaust mounting set - BASIC

$12.00

qty:

here's what ya get in this PARTYYY!:

2 of moped M6 x 30mm CHROME exhaust or intake stud in GOLD ($4.70 value!)
2 of flat washers - M6 ($.27) ($0.54 value!)
2 of M6 (10mm) LONG brass exhaust nut ($6.50 value!)
1 of malossi puch + tomos metal lined exhaust gasket ($3.49 value!)

nice little exhaust mounting kit for puch and tomos mopeds!!

there are some slight variations, so make sure your stud hole center to center is about 42.5mm

ID of exhaust gasket is about 25mm, so will work with kits and even fine with stock too

comes with super useful long brass exhaust nuts that make tightening on your pipe easier if there are some header complications

you get some m6 studs, too, and flat washers. all the goodies!

and you know, there really is the right way to install a pipe, too!! maybe youve been doing it wrong??

the best way is to:

1. install studs using the double nut technique...tighten two m6 nuts against each other on the stud then thread it into the cylinder using force only on the bottom nut. once fully in, hold the top nut with a wrench and loosen the bottom nut, then get em both off!

or

install with an m6 stud installer!!

2. hold the exhaust gasket on, hold the back of the pipe up and then push the header holes through the studs. pretty tricky. some people use there leg, or finger tricks, or whatever. you develop your own technique...

3. grab a washer and brass nut and thread one on. thread the others on after.

4. begin to tighten down your pipe while supporting the rear loosely. keep going until the pipe lays exactly WHERE IT WANTS TO GO. you NEVER tighten down the rear part of your pipe first!!! this is the biggest mistake. this will result in loosened nuts and leaks, pipes cracking, pipes falling off, etc....this is because you are putting force on the cylinder and pipe where it does not naturally fall, so keep this in mind!!

maybe you already knew all of that? thats rad! definitely wish someone told me my first time though!!

taco rating taco rating 5 of 5

5 of 5 Total Reviews: 1 give your taco rating here

0 taco eaters like this review

too hot	September 20, 2023
taco eater : Arron Gray from Fort Thomas, KY United States

the packaging tape said to refrigerate. my wife did exactly that. thank you treats for the laugh

everything worked like a charm on the puch e50

Was this review helpful to you?

treatland